DPF Cleaning Birmingham

Mobile on-car cleaning, off-car factory cleaning and replacement across Birmingham and the wider West Midlands

Mobile DPF cleaning at your home, workplace or depot from Edgbaston and Moseley to Erdington, Solihull and Sutton Coldfield – for cars, light commercial vehicles (LCVs), HGVs and plant machinery. Usually same-day or next-day.

Birmingham drivers know the pattern: stop-start traffic on the ring road, short hops around the Clean Air Zone, and long queues through interchanges like Gravelly Hill. None of that gives a diesel particulate filter much chance to reach the temperature it needs to regenerate properly, which is why DPF warning lights, limp mode and failed regenerations are such a common complaint across the city.

DPF Fixer provides mobile DPF cleaning across Birmingham and the wider West Midlands, along with off-car cleaning and DPF replacement, for private motorists, garages, taxi and private hire operators, and commercial fleets. Wherever you’re based in the city, we can usually get an engineer to you the same or next day.

Call 0333 366 1404 for advice or to book.

Why Birmingham Drivers and Businesses Choose DPF Fixer

Frequent short trips, stop-start traffic around the ring road and low-speed driving through the Clean Air Zone rarely let the exhaust reach the temperature a filter needs to regenerate naturally. Here’s what we offer Birmingham drivers and businesses:

Mobile coverage across Birmingham and the surrounding West Midlands, usually same-day or next-day.

On-car and off-car cleaning, plus replacement support, so you’re not passed between providers.

Clear pre- and post-clean diagnostic reports you can keep, plus a 30-day aftercare warranty on every clean.

ISO 9001 and 14001 certified, with Safe Contractor and SSIP accreditation — see our About Us page.

Vans and cars doing mostly local drops, school runs or short commutes across areas like Kings Heath, Moseley or the Jewellery Quarter are more likely to develop a restriction over time, even if warning lights haven’t appeared yet. Catching it early with a professional clean is almost always cheaper than waiting for a filter to block completely.

Our DPF Services in Birmingham

Our approach throughout is straightforward: clean first where suitable, replace only where necessary. Cleaning restores the majority of filters we see, and it’s almost always the faster and more cost-effective route.

Mobile clean at your home, workplace or roadside

1. On-Car (Mobile) DPF Cleaning

For most Birmingham vehicles showing a DPF warning light, reduced power or a regeneration that won’t complete, a mobile on-car clean is the sensible first step. One of our engineers comes to your home, workplace or roadside location anywhere in the city — from Edgbaston, Moseley and Kings Heath to Erdington, Northfield, Solihull and Sutton Coldfield — carries out a full diagnostic check, deep-cleans the filter in situ, and finishes with a monitored regeneration before handing the vehicle back, usually within a couple of hours. There’s no need to book a slot at a garage or go without your car for days. Every clean comes with our 30-day warranty.

Arrange booking

Off-car factory clean, dispatched back within 48 hours

2. Off-Car DPF Cleaning

Some vehicles can’t be helped with an on-car clean — typically because the vehicle won’t start, or because the blockage is linked to an EGR, turbo, injector, glow plug or AdBlue fault that means the filter needs to come out anyway. Birmingham garages, workshops and account holders who can remove and refit their own units can use our off-car factory cleaning service instead: box up the DPF, our courier collects it, and it’s deep-cleaned, pressure-tested and dispatched back within 48 hours. We regularly support independent garages around Digbeth, Nechells and Aston with this express turnaround, which keeps their own customers’ cars moving without tying up a ramp. Full details are on our off-car cleaning page.

Book off-car clean

3. DPF Replacement

Occasionally a DPF has gone beyond recovery — a cracked substrate, a collapsed matrix or physical damage to the casing — and cleaning genuinely won’t restore proper flow. In these cases we can advise on and supply a replacement DPF for Birmingham customers, so you’re not left choosing between an unroadworthy car and an unnecessary bill. You can order directly through our online DPF and CAT shop.

Visit our online shop

Note on “DPF delete”: it’s illegal to drive a vehicle in the UK with the DPF removed, and doing so will fail an MOT and can carry fines from £2,000 upwards. If a garage suggests this, we’d always recommend cleaning or proper replacement instead.

DPF Cleaning for Birmingham Businesses and Fleets

Private drivers: If your dashboard has lit up with a DPF, engine or “reduced power” warning, or the car has gone into limp-home mode, call us for straightforward advice before you book anything. Most on-car cleans are completed on-site within a couple of hours, so you’re not left without the car.

Businesses & fleets: Birmingham is one of the busiest trade and logistics hubs outside London, from the distribution units around Birmingham Business Park and Junction 6 of the M42 to the taxi and private hire vehicles working the city centre and the independent garages of Digbeth and Nechells. A van, taxi or plant vehicle sitting off the road with a DPF fault is a vehicle that isn’t earning. Our commercial and fleet service covers fleets, HGVs, PSVs, garages and plant or agricultural equipment operating in and around Birmingham:

A dedicated trade line and business account pricing

On-car and off-car cleaning, to suit how your workshop operates

Scheduled preventative cleaning, so vehicles spend less time off the road

Replacement support where a filter is genuinely beyond cleaning

Cover for HGVs, PSVs, plant and agricultural equipment as well as cars and vans

For trade pricing, call our commercial team on 0333 366 1404.

Birmingham Case Studies

A flavour of the kind of jobs we handle across the city each week. These are illustrative examples, not individual customer testimonials.

Kings Heath – mobile clean on the drive at home

Private motorist, Kings Heath

A Ford Focus began losing power on the Alcester Road, with the DPF light on and the engine noticeably down on performance. The owner’s regular garage had quoted for a full replacement unit. Our engineer attended the same afternoon, confirmed via diagnostics that the filter itself was structurally sound and simply heavily restricted, and completed a mobile clean and regeneration on the drive at home — restoring normal power without the cost of a new DPF.

Birmingham Business Park – rolling preventative schedule at the depot

Delivery fleet, near Birmingham Business Park

A small delivery firm running five diesel vans out of a depot near the M42 was seeing repeated DPF warnings across the fleet, largely down to short urban drops around the city centre. Rather than dealing with each breakdown reactively, we set up a rolling preventative cleaning schedule, visiting the depot outside peak delivery hours so vehicles could be cleaned in turn without taking a van off the road during the working day.

Digbeth – off-car clean, back with the garage next morning

Independent garage, Digbeth

A local garage had a Transit in for an EGR fault that had also left the DPF heavily blocked, and the van wouldn’t start to allow an on-car clean. The garage removed the unit and booked it in for our off-car service; our courier collected it, it was deep-cleaned and pressure-tested the same day, and it was back with the garage the following morning ready to refit — well within their customer’s promised turnaround.

Birmingham Areas We Cover

Our mobile engineers cover Birmingham city centre and the surrounding boroughs, including:

Birmingham city centre · Edgbaston · Moseley · Kings Heath · Erdington · Northfield · Solihull · Sutton Coldfield · Halesowen · Digbeth · Nechells · Aston · Jewellery Quarter · Dudley · Walsall · Wolverhampton · Coventry

If you’re unsure whether your postcode is covered, call our booking line on 0333 366 1404 and we’ll confirm availability.

Frequently Asked Questions — DPF Cleaning in Birmingham

These are the questions we’re asked most often by Birmingham customers. For general DPF questions covering the whole of the UK, see our main FAQ page.

Do you cover the whole of Birmingham and the surrounding area?

Yes. Our mobile engineers cover Birmingham city centre and the surrounding boroughs, including Solihull, Sutton Coldfield, Erdington, Edgbaston, Northfield, Kings Heath and Halesowen, as well as neighbouring towns such as Dudley, Walsall, Wolverhampton and Coventry. If you’re unsure whether your postcode is covered, call our booking line and we’ll confirm availability.

Will a DPF clean stop me being charged in Birmingham’s Clean Air Zone?

Birmingham’s Clean Air Zone charges non-compliant vehicles for entering the area inside the A4540 Middleway, based on their Euro emissions standard rather than how well the DPF happens to be working on the day. A professional clean restores the filter’s performance and helps the vehicle run and regenerate as it should, but it doesn’t change a vehicle’s underlying Euro rating. If your vehicle is already Euro 6 diesel or Euro 4 petrol and simply has a blocked filter, cleaning it can help keep it running cleanly and passing emissions-related MOT checks. For the current daily charge and exemptions, check the GOV.UK Clean Air Zone checker.

My car rarely leaves Birmingham city centre. Is that likely to cause DPF problems?

Yes, this is one of the most common causes of DPF problems we see in the city. Frequent short trips, stop-start traffic around the ring road and low-speed driving through the Clean Air Zone rarely let the exhaust reach the temperature needed for the vehicle to regenerate the filter naturally. Vans and cars doing mostly local drops, school runs or short commutes across areas like Kings Heath, Moseley or the Jewellery Quarter are more likely to develop a restriction over time, even if warning lights haven’t appeared yet.

I’m a Birmingham taxi driver and my DPF warning light is on — what should I do?

A persistent DPF fault can affect both performance and emissions compliance checks, and every hour off the road costs you fares. Rather than continuing to work the vehicle with the warning light on, it’s worth getting it assessed promptly. Many of our taxi and private hire customers book a mobile clean around their shift pattern to minimise time off the road.

Do you clean DPFs on Land Rovers and Range Rovers in Birmingham?

Yes. With Jaguar Land Rover’s Solihull plant on the doorstep, Birmingham and the surrounding area has one of the highest concentrations of Land Rover and Range Rover diesels in the country, alongside vans and cars from all major manufacturers. Our engineers are experienced with these models’ DPF systems and carry the diagnostic equipment needed to assess and clean them on-site.

My van won’t start at my garage in Nechells, can you still help?

Yes. If the vehicle won’t start, an on-car mobile clean isn’t possible, but that doesn’t rule out cleaning the filter. The DPF can be removed and sent to us, or brought in by your local garage, for our off-car factory cleaning service, with a 48-hour turnaround. This is the same service we regularly provide to garages in that part of the city.

How much does DPF cleaning cost in Birmingham?

Pricing depends on the vehicle and the extent of the blockage, so we ask a few quick questions about the symptoms and vehicle type before quoting an accurate price. This also helps us confirm that cleaning, rather than replacement, is the right route. Call our booking line for a price specific to your vehicle.

Book Your DPF Clean in Birmingham

Got a DPF warning light in Birmingham? Call DPF Fixer on 0333 366 1404 and we’ll advise on the right next step for your vehicle — whether that’s a mobile clean, an off-car service, or replacement.
Every clean includes pre- and post-clean diagnostic reports you can keep, and a 30-day aftercare warranty. Our lines are open 7.30am–6.30pm Monday to Thursday and 7.30am–5.30pm on Fridays.
To get in touch or book a visit out of hours, fill in the form below and we’ll get back to you as soon as possible.

Trade and Fleet enquiries

For trade and fleet contracts please call us on 0333 366 1404

Official Partners